Yahoo Message Number: 80252 (http://groups.yahoo.com/neo/groups/Country-Coach-Owners/conversations/messages/80252)
I just installed a new controller, pt# 909510000, which is the manufacturers designated replacement for the older controllers, pt# 909570000 used on a lot of our coaches. The steps now work backwards, open door - steps retract, close door - steps extend. After a little investigation, I traced the problem to the normally closed switch in my door. It needs to be a normally open switch.
I contacted Kwikee this morning and was told that a design change took place affecting units shipped after February, 1999, which requires a normally open switch. Not totally believable since that would mean that CC used 5+ year old step inventory on my 2005 coach, an unlikely scenario. I don't really know what is going on, but just be aware that there is a door switch issue with Kwikee controllers if the steps operate backwards after replacing the controller.
Yahoo Message Number: 80254 (http://groups.yahoo.com/neo/groups/Country-Coach-Owners/conversations/messages/80254)
I just noticed I put an extra zero on both the part numbers. They just have 3 zeros at the end, not 4.
Yahoo Message Number: 80256 (http://groups.yahoo.com/neo/groups/Country-Coach-Owners/conversations/messages/80256)
I've read about this same issue and the suggested solution was to reverse the wires on the motor. I don't know if it works?
Larry, 03 Allure 30856
Yahoo Message Number: 80257 (http://groups.yahoo.com/neo/groups/Country-Coach-Owners/conversations/messages/80257)
Stuart:
This is a common problem now when changing out to these new controllers, what you need is a Reversing harness (Which I now have in stock), this plugs in between the motor & controller & reverses the switch.
Kevin Waite (Former Country Coach Service Tech.) K&M Mobile R.V. Repair LLC
95430 Noraton Rd.
Junction City, OR. 97448
541-953-6162 (Cell)
kvn.wt.7629@... (kvn.wt.7629@...)
Yahoo Message Number: 80258 (http://groups.yahoo.com/neo/groups/Country-Coach-Owners/conversations/messages/80258)
Larry:
I do not believe that will work.
Kevin Waite
Yahoo Message Number: 80260 (http://groups.yahoo.com/neo/groups/Country-Coach-Owners/conversations/messages/80260)
According to Kwikee, the steps will then work in the proper direction, but ignition overide and last out feature will not work correctly.
Yahoo Message Number: 80261 (http://groups.yahoo.com/neo/groups/Country-Coach-Owners/conversations/messages/80261)
The reversing harness will take care of ALL of these issues.
Kevin Waite
541-953-6162 (Cell)
kvn.wt.7629@... (kvn.wt.7629@...)
Yahoo Message Number: 80287 (http://groups.yahoo.com/neo/groups/Country-Coach-Owners/conversations/messages/80287)
Kevin, thank you for the reply. Sending you a PM shortly.
I also need to correct two mis-statements I made. The part numbers do have the 4 zeros on the end for the controller in a series 42 Kwikee step. 909570000 (old) and 909571000. Sorry.
I also said the reason for my steps operating backwards was because of a normally closed instead of a normally open door switch. Not true after I got inside the door to replace it. It is a n/o switch for the steps, with a n/c side to turn on and off the coach floor entry light. Again, sorry.
Here is a pdf for the series 42 steps that is the best doc I have seen regarding these steps. FYI
Stuart Thornton, 2005 Allure, #21317
Yahoo Message Number: 80295 (http://groups.yahoo.com/neo/groups/Country-Coach-Owners/conversations/messages/80295)
Geeze, I can't even seem to get anything right. I forgot to include the link to the Kwikee Series 42 PDF file. Here it is: http://support.powergearus.com/techdocs/1422258.pdf (http://support.powergearus.com/techdocs/1422258.pdf)
Stuart, 2005 Allure, #31217