Skip to main content ↑ ↓
Topic: Hydro hot inop (Read 1683 times) previous topic - next topic
0 Members and 1 Guest are viewing this topic.

Hydro hot inop

Yahoo Message Number: 107839
Our coach has a hydro hot system. No hot water for DW's shower. HH status board The bay shows low coolant fault. Overflow bottle was low so I added 50/50 mix to fill bottle per HH instructions. Checked the main tank by loosening the pressure cap and tank was full. HH. Instructions say that the fault should self clear when coolest level is restored but is is still showing red on the status board. Trouble shooting. Checked breaker on coach, Status board has power. Green status on burner and pump. No other red status faults. No hot water, no eng preheat, no furnace heat. Basically the burner won't spin up. No elec. hear either. I will call HH tomorrow when we get to where we have cell service, but in the meantime, ideas?? Jim and Jo

Jim and Jona Seifert

jim.jona.seifert@... 2007 Country Coach Intrigue Ovation 530 42' Coach #12150

525 Cat C13 Allison 6spd

Toads: 2014 Ford F150 / 2007 Toyota FJ Cruiser w/ REMCO DS Disconnect.
Airforce 1 Brake system
Blue Ox Aventa II Towbar
Jim and Jona Seifert
2007 Intrigue 530

Re: Hydro hot inop

Reply #1 –
Yahoo Message Number: 107840
Try pushing in the reset button on the status board, takes a paper clip or tiny pointed instrument like a toothpick.

Harvey.

06 magna 6670

Re: Hydro hot inop

Reply #2 –
Yahoo Message Number: 107841
Boiler fluid float maybe faulty.

Their is a work around. Remove metal cover and find two Yellow wires. Wires are easy to disconnect.
Remove and hook up jumper wire with inline fuze ( 10 amp).
Be real sure your boiler fluid is full.
See if that works. This is only temp rill you can get float replaced.
Good luck.

Kent. 05 Allure. 31281

Re: Hydro hot inop

Reply #4 –
Yahoo Message Number: 107844
Here is a site that will also help you with your Hydro-Hot.  RV Hydronic Heater Forum          RV Hydronic Heater Forum  RV Hydronic Heater Repair        I used it when my system stopped working correctly.  He will answer question posed to the group/forum. I did have to join his group, but no ads or anything like that came back to me because of joining. He is a very knowledgeable person and you can get parts from him. Dave07  Country Coach Allure 430 #3149512 Jeep GC ToadMountains of So Cal    andHenderson, Nev      From: "Tom Hatchell thatchell@... [Country-Coach-Owners]"  To: Country-Coach-Owners@yahoogroups.com  Sent: Sunday, August 28, 2016 6:48 AM Subject: Re: [Country-Coach-Owners] Hydro hot inop Check aguahot.com for manuals. I had same problem and it was the fluid level sensor. 08 CC Intrigue Ovation #12046
Dave & Jodi
2007 CC Allure 40’ Tag #31495
2012 Jeep GC
Big Bear Lake, Ca & Henderson, Nev
 

Re: Hydro hot inop

Reply #7 –
Yahoo Message Number: 107865
All: As I suspected but was unable to prove, I think the float was stuck. We were at the Apostle Island in northern Wisconsin and on the water most of the weekend so, no cell service. When we drove home to MN yesterday, the ride on old WI-13 must have bounced the float loose, by the time we got home we had hot water! My plan was to jumper the float when I got home until I could get a replacement part but fortunately I didn't have to. I've save the URL of the forum. Good to know. Thanks for all the great advice!
Jim and Jona Seifert
2007 Intrigue 530