Skip to main content ↑ ↓
Topic: 06 Allure Cummins non-start (Read 1030 times) previous topic - next topic
0 Members and 1 Guest are viewing this topic.

06 Allure Cummins non-start

Yahoo Message Number: 20340
Has anyone had this problem?

If we sit in a site for several days (this last time only 6 days) without starting the engine, we have to use the engine boost because it is dead. It always starts with the boost but this doesn't seem like the right way to do business. (Our '06 Allure is only 4 months old.)

Any suggestions?

sob, 06 Allure 31290

Re: '06 Allure Cummins non-start

Reply #1 –
Yahoo Message Number: 20341
Re: [Country-Coach-Owners] '06 Allure Cummins non-start Had the same problem on my Intrigue. The CC crew at Beaudry changed out the echo charger and said that it is a common failure. No problems since.

Dick B

04 Intrigue 11830

At 1:40 PM -0700 1/8/06, Shirley O'Brien wrote:

Re: '06 Allure Cummins non-start

Reply #2 –
Yahoo Message Number: 20342
Ditto on the EchoCharger. Ours was the same way. Once Beaudry swapped for new one, voila, no problems.

Bob

'05 Intrigue Ovation #11872

Quote from: Dick Bradley\[br\
]
Had the same problem on my Intrigue. The CC crew at Beaudry

changed

Quote
out the echo charger and said that it is a common failure. No > problems since.

Dick B

04 Intrigue 11830

At 1:40 PM -0700 1/8/06, Shirley O'Brien wrote: > >Has anyone had this problem?
>

>If we sit in a site for several days (this last time only 6 days) > >without starting the engine, we have to use the engine boost

because it

Quote
is dead. It always starts with the boost but this doesn't seem

like

Quote
the right way to do business. (Our '06 Allure is only 4 months

old.)

Quote

>Any suggestions?
>

>sob, 06 Allure 31290
>
>
>
>

> Visit your group

>"http://groups.yahoo.com/group/Country-Coach-Owners>Country-
Coach-Owners"

Quote
on the web.
>

> ">Country-Coach-Owners-unsubscribe@yahoogroups.com?
subject=Unsubscribe>Country-Coach-Owners-unsubscribe@yahoogroups.com

Re: '06 Allure Cummins non-start

Reply #3 –
Yahoo Message Number: 20344
I recently had the same problem and switched out the echo charger. It only took about 20 minutes. The echo charger should be located right next to the inverter. West Marine has them online if CC won't cover it.
http://www.westmarine.com/webapp/wcs/stores/servlet/ProductDisplay?storeId=10001&langId=-1&catalogId=10001&productId=29835
Rob

'02 Intrigue - #11480

Re: '06 Allure Cummins non-start

Reply #4 –
Yahoo Message Number: 20345
Yes, I had that problem.

In my case the echo charger was not charging when on shore power. After several dead batteries and lots of calls to Country Coach, I was unable to fix the problem.
I finally called the echo charger factory and got lots of help. What I found out was Country Coach reverse wired the echo charger at the factory. The echo charger never worked the first 8 months I had the coach. With the coach on shore power you should have a steady green light on the echo charger. I had a flashing green light which basicly means the system is not charging. It was very easy to switch the wires at the echo charger, and I haven't had problems since.
I would say make sure you have a steady green light on your echo charger when hooked up. If you don't I would let Country Coach know and go from there.
You are right something is very wrong if you have to use your boost after a short stay.
Good luck!
Jim

2005 40' Inspire #51225

Re: '06 Allure Cummins non-start

Reply #5 –
Yahoo Message Number: 20346
The echo charger fuse is usually the problem. I have had the fuse blow 2 times on my magna . It is an inline fuse that is just a few inched from the echo charger. Please check this before paying someone to replace the echo charger.

Re: '06 Allure Cummins non-start

Reply #6 –
Yahoo Message Number: 20347
I had the same problem in 2000/2001 on a then new coach.
But my echocharger wasn't bad, just factory wired incorrectly (charging the house batteries from the engine/coach batteries instead of the other way around).

In my coach, that was an easy mistake, since both wires from the echo charger to either battery are connected to the battery boost solenoid.

Bringing it to my dealer (where I bought it) complaining about it never got it resolved until I wised up and started finding out how things are supposed to work.

By that time, the coach batteries had gone bad due to lack of charge.

Maybe some of those replaced echochargers were not really bad, just miswired?

Henk Bots, Magna 5624.

Quote from: Bob Stephens

Re: '06 Allure Cummins non-start

Reply #7 –
Yahoo Message Number: 20348
Have experienced the same problem with my 06 Inspire. CC sent me a new Echo Charger after spending 30 min to change it. (Small bay to crawl into on your back). Bottom line the new Echo Charger did not work either. Seveal call's to CC about it and the problem was the circut breaker that sent the charge to the battery was poped out. Reset it and the new Echo Charger was giving charging green light.
Would highly recomment checking all the circut breakers as this may also be your problem. It was mine.

Ed Falgout
06 Inspire
51555
 

Re: '06 Allure Cummins non-start

Reply #8 –
Yahoo Message Number: 20349
I had checked all the wiring of the EchoCharger and the breakers and the fuse. A replacement part got us back on the road to happy charging.
Bob

'05 Intrigue Ovation #11872

Quote from: Henk J\. Bots
>

I had the same problem in 2000/2001 on a then new coach.
But my echocharger wasn't bad, just factory wired incorrectly > (charging the house batteries from the engine/coach batteries

instead

Quote
of the other way around).

In my coach, that was an easy mistake, since both wires from the

echo

Quote
charger to either battery are connected to the battery boost

solenoid.

Quote
>

Bringing it to my dealer (where I bought it) complaining about it > never got it resolved until I wised up and started finding out how > things are supposed to work.

By that time, the coach batteries had gone bad due to lack of

charge.