Skip to main content ↑ ↓
Topic: Flojet Water Pump Problems (Read 1506 times) previous topic - next topic
0 Members and 1 Guest are viewing this topic.

Flojet Water Pump Problems

Yahoo Message Number: 22221
I have a 2004 Allure that has a very noisy water pump. It also chatters a lot after turning off. I cleaned the pre filter without any improvement. I also tried to change the pressure switch setting.
I contacted Flojet and was advised that this problem was probably due to air in the lines. No air in the lines. I finally purchased a new pump which I will install in the next week or so. My question is, has anyone out there had a similar problem and if so, what did you do to solve it?

Lou...coach #31039

Re: Flojet Water Pump Problems

Reply #1 –
Yahoo Message Number: 22222
Check the lines and isolate them from touch each other and especially from touching the fibre glass panels. Heard of others using flexible lines to connect the pump and mounting it to a panel which is isolated from the floor. The noise was my first complaint.
TWI 2004 Intrigue 11731

Re: Flojet Water Pump Problems

Reply #2 –
Yahoo Message Number: 22225
No problems with my CC pump yet, but in my cheap-o trailer, the water pump sounded like a 747 landing on a washboard. The dealer put in flexible lines, enclosed them in that pipe insulation and added rubber mounts. Helped some, but still made noise on occasion. In fact I had just bought a new pump right before looking at the new coach, but now its a moot point, of course (traded it in).

John 04 Inspire 51078

Quote from: TWI
Check the lines and isolate them from touch each other and
especially from

Quote
touching the fibre glass panels. Heard of others using flexible

lines to

Quote
connect the pump and mounting it to a panel which is isolated from

the

Quote
floor. The noise was my first complaint.
TWI 2004 Intrigue 11731 >

Re: Flojet Water Pump Problems

Reply #3 –
Yahoo Message Number: 22249
Lou,

On my last coach I had to insulate the water hoses wherever they made contact with anything near the pump. I used the foam pipe insulation. You also need to be sure the pump is insulated from its mounting - usually rubber grommets.
 

Re: Flojet Water Pump Problems

Reply #4 –
Yahoo Message Number: 22303
Lou, I have Allure #31038. Owned since new. My FloJet pump has given no problems but is not impressive on flow rate or pressure. In my last SOB I replace FloJet with the new variable pump from the same company and was very pleased with the results.

George in Birmingham
'04 Allure 31038

[quote author=widgielk" polaski@\.\.\.\>] >

I have a 2004 Allure that has a very noisy water pump. It also > chatters a lot after turning off. I cleaned the pre filter without > any improvement. I also tried to change the pressure switch [/quote]
setting.

Quote
I contacted Flojet and was advised that this problem was probably due > to air in the lines. No air in the lines. I finally purchased a new > pump which I will install in the next week or so. My question is,

has
George in Birmingham
2003 Magna 6298