Skip to main content ↑ ↓
Topic: Air dryer cartridge model? (Read 1879 times) previous topic - next topic
0 Members and 1 Guest are viewing this topic.

Air dryer cartridge model?

Yahoo Message Number: 104299
Does anyone know the Bendix number for the air dryer cartridge on our coaches? Also the number for the entire air dryer unit? Rich 2002 Magna

Sent from Outlook Mobile

Re: Air dryer cartridge model?

Reply #1 –
Yahoo Message Number: 104309
Hi Rich,

I believe you are looking for a Bendix 109493X. This is the rebuilt filter but it is as good as a new one.

http://www.banddtruckpartsstore.com/Bendix-New-Desiccant-Cartridge-Ad-Ip-New-109493X_p_725.html

The unit is a Bendix AD-IP but I don't have a number for it. (It's possible your 2002 uses a different drier.)

Barney

07 Inspire 52059

---In Country-Coach-Owners@yahoogroups.com,  wrote :

Does anyone know the Bendix number for the air dryer cartridge on our coaches? Also the number for the entire air dryer unit? Rich 2002 Magna

Sent from Outlook Mobile

Re: Air dryer cartridge model?

Reply #2 –
Yahoo Message Number: 104310
Does anyone know the location of the air dryer on a 2000 Magna Cat C-10 and the number?

Don

2000 Magna Cat c10

Re: Air dryer cartridge model?

Reply #3 –
Yahoo Message Number: 104321
I think the air dryer cartridge on our 99 Magna was forward and above the passenger side rear axle. Not an easy place to get to unless your 12.

Tammy Toalson

2006 Affinity 6611
was

1999 Magna 5605

Re: Air dryer cartridge model?

Reply #4 –
Yahoo Message Number: 104323
Rich

I don't believe the CAT and Cummings were the same. As I remember I crawled under and got the number off of the unit.

Don't forget the purge valve if has been a while since the desiccant filter was changed. There used to be a rebuild kit for the purge valve but I believe it was discontinued. Bendix tech support is very helpful and there are a number service pubs that you can download. Buy the parts from a distributor and take them to your service shop it will save you a lot of money. Plus you will not have to wait for them to order in the parts. There use to be a core charge for the remanufactured filter but the last time I changed it out they were not asking for the filter to be returned.

Dan 2006 Allure 31348 C-9       
Dan

Re: Air dryer cartridge model?

Reply #5 –
Yahoo Message Number: 104326
Our 2002 Affinity with C-12 CAT uses the Bendix Remanufactured AD-IP Air Dryer 109477X. It was $216.93 after return of the core at Pacific Truck Center and $220.00 to install at Peterson CAT, both in Eugene, OR.

FWIW

Dave M. 2002 Affinity #6103
Dave & Cathy M, 2002 Affinity #6103, 2018 GMC Acadia, Linux Mint 19.2

Re: Air dryer cartridge model?

Reply #6 –
Yahoo Message Number: 104363
What is the air dryer number for 2000 Intrigue with ISC 350 engine?

Ray

2000 Intrigue 11040

Re: Air dryer cartridge model?

Reply #7 –
Yahoo Message Number: 104375
We replaced our drier last summer on our 2000 C10 Magna. It is located in front and above the rear axle.I was fortunate that I had a pit to access it. After doing it I would not even attempt it without a pit. To get the drier out required disconnecting the some of the brake air lines, drier air lines, loosening a support band and a pair of mounting bolts. Then you need to snake it down and out.

It took several attempts to get the correct drier. We wanted to just replace it with a rebuilt drier assemble. When you examine the dryer assembly you will notice it has an extra air line that is not found on the rebuilt units. We were told that if the new/rebuilt drier does not have that extra line it will cause early failure of the compressor. The parts house (Esley Truck Accessories in Salem, OR) took the time to research the issue. To get the correct rebuilt drier assembly it would be a special order. There were only 3 on the shelf at the rebuild factory and it would take 3 days to get. The other option was to install a drier rebuild kit. Needless to say we bought a dryer rebuild kit and installed it.

Rebuilding the drier assembly ourselves was not that difficult.A big vise was handy because you can clamp the drier assembly to remove and install the dryer cartridge. Difficulty of rebuilding is a 2 or 3, you just need big tools. All parts (i.e., drier cartridge, purge valve and gaskets) were included in the kit. Since we dissembled the unit to replace the drier cartridge we were able to inspect the internals. We noted there was no moisture on the outlet of the drier; that would lead me to believe that the desiccant was not consumed.

Frank

2000 Magna 5766

Re: Air dryer cartridge model?

Reply #8 –
Yahoo Message Number: 104382
Frank,

This is very useful. Thanks. Is you dryer a Bendix AD-P1 or some other model? You probably don't know the answer, but do you have reason to believe that later models of Magna had the extra air line? Do you have any idea why not just replace the cartridge and not rebuild the purge valve?

Rich 2002 Magna
 

Re: Air dryer cartridge model?

Reply #9 –
Yahoo Message Number: 104400
The air dryer an the 2000 magna is on top of the rear axle.

Bo & Kathy Lee 2000 Magna #5896 40 FT 2006 Jeep Wrangler Unlimited Rubicon

On Saturday, January 2, 2016 4:27 PM, "barneym@... [Country-Coach-Owners]"  wrote:

Hi Rich,

I believe you are looking for a Bendix 109493X. This is the rebuilt filter but it is as good as a new one.

http://www.banddtruckpartsstore.com/Bendix-New-Desiccant-Cartridge-Ad-Ip-New-109493X_p_725.html

The unit is a Bendix AD-IP but I don't have a number for it. (It's possible your 2002 uses a different drier.)

Barney

07 Inspire 52059

---In Country-Coach-Owners@yahoogroups.com,  wrote :

Does anyone know the Bendix number for the air dryer cartridge on our coaches? Also the number for the entire air dryer unit? Rich 2002 Magna

Sent from Outlook Mobile