Skip to main content ↑ ↓
Topic: Caterpillar C9 (Read 814 times) previous topic - next topic
0 Members and 1 Guest are viewing this topic.

Caterpillar C9

Yahoo Message Number: 21225
Just in case anyone is interested, I recieved a call today from the Cat factory that they just released a new reflash for the C9. This program (part# 289-1223) should help if you have an issue with engine surging or black smoke.
Jim

2005 40' Inspire #51225

Re: Caterpillar C9

Reply #1 –
Yahoo Message Number: 21228
Quote from: tigerlinksmr
> > Just in case anyone is interested, I recieved a call today from the Cat > factory that they just released a new reflash for the C9. This program > (part# 289-1223) should help if you have an issue with engine surging > or black smoke.

Jim

2005 40' Inspire #51225

Jim Thanks for the info on the C-9. Yes, We have that issue. Also, a shift problem
sometimes which someone wrote about, saying Cat and Allison have a hook up computer issue. Also, does your engine indicate about 210 to 215 degrees when running down thew highway??? Ned Inspire 51677

Re: Caterpillar C9

Reply #2 –
Yahoo Message Number: 21235
Ned and Warren,

When I talked with Cat they did say this new update would also take care of the shift problems that some owners are experiencing.
To get the details, I would call Caterpillar RV support at: 1-877-777-3126.
My engine temp is often around 210 to 215 degrees on the gage, which reads about 12 degrees more than the ECM readings.
Good luck,
Jim

2005 40' Inspire #51225

Re: Caterpillar C9

Reply #3 –
Yahoo Message Number: 21236
I have an Allure 2003 running a Cummings. I have had temp raise also, i think the thermosates in these enjoys need replacing about every three years. I read this in an article I believe in "Destination".
When I get a warning light I drop a gear and back off some, light goes out, temp drops. When I have just notice surges, temp. usually reaches about 215, and then just opens on its own and drops off. I look at thermosate on Cummings does not look like a big change issue. Also when I pick my coach up from CC last summer I was four gallons short of coolant. I am using the recommmeded premix which is a Cummings product and that could also be apart of my issue.

Keep safe. see you all on the road.

Thank you,

Jim Spivey
 

Re: Caterpillar C9

Reply #4 –
Yahoo Message Number: 21239
If temperature is still giving people problems, back in the fall of 2004 I posted pictures that are in the photo area of the CC experimental coach being tested in Arizona with various modifications.
I have done most of them on my 2002 Allure with the results being lowered temperature on the both the engine and transmission. If you do not have a louvered engine door, you can make a couple of support arms that hold the door open. Pictures are posted in the photo area.
This made a 20 degree difference. The flap added below the radiator stops hot air from re-circulating when at idle. My louvers are not nearly as large as those on the CC coach, but seem to help some. I have built a screen that keeps hands out of the engine compartment when the door is open. It stays in place when the door is closed.
Aircraft quick release pins allow the screen to be removed in a few seconds to check engine oil etc. One CC owner that visited us when in Seal Rock modified his Coach with the support arms with similar results. John
2002 Allure
#30702