Skip to main content ↑ ↓
Topic: 2005 Allure Click-No-Crank (Read 1232 times) previous topic - next topic
0 Members and 1 Guest are viewing this topic.

2005 Allure Click-No-Crank

Hello fellow Country Coach road warriors!
I loaded up the coach to head out to Colorado on Sunday and it would not start and the solenoid was doing a rhythmic clicking.  Did the following troubleshooting steps and want a sanity check as to what is wrong:
1. checked the chassis batteries terminals - clean and tight.
2. checked battery voltage - 12.7v off shore power
3. load tested the Lifeline AGM batteries - tested good with no draw.
4. checked battery voltage at solenoid - 12.7v on shore power. 12.2 and decreasing off shore power
5. jumped the large lugs on the solenoid - motor spun freely but did not engage the flywheel
6. thoroughly cleaned the large ground cable and terminal at the rear of the starter motor - no change
6. connected a remote starter to the small terminals on the solenoid - solenoid clicks rhythmically
6. tapped solenoid with hammer - no change

Seems like a bad solenoid to me but I was wondering if there is anything else I should check before replacing the starter motor and solenoid.  The transmission pad lights up, is in neutral and the dash instruments function.

2005 Country Coach Allure 470 McKenzie Bridge with about 56K miles